چکیده:
این مقاله با استفاده از نمونه های قالی که توسط یک بافنده از مواد اولیه یکسان و کاربرد چهار نوع گره متقارن، نامتقارن، جفتی و بی گره بافته شده اند، تاثیر این گره ها بر خواص فیزیکی قالی شامل عرض بافت، طول نقش مایه ها، طول گره و وزن را اندازه گیری می کند. نمونه های بافته شده در دو روش تولید شدند. نتایج نشان می دهند که عرض نمونه های جفتی و بی گره پس از پایین آوردن از دار کاهش می یابد، در حالی که کاهش عرض در نمونه های متقارن و نامتقارن بسیار اندک است. طول نقش مایه ها بستگی به میزان تغییر ابعاد فرش دارد و در نمونه هایی که تغییر ابعاد رخ داده است، ابعاد نقش مایه نیز تغییر کرده و در مواردی که تغییر ابعاد در فرش ایجاد نشده، نقش مایه ها نیز دست خوش تغییر نشده اند. در عین حال با بررسی کیفی نقوش ایجاد شده در چهار نمونه، تغییراتی که در اجزای نقش مایه به وجود آمده و از نظر وضوح نقش تفاوت هایی که بین نمونه های مختلف پدید آمده است نیز مورد بحث قرار گرفته اند. با بررسی طول گره مشخص شد که بیشترین طول گره مربوط به گره جفتی و کوتاه ترین گره مربوط به بی گره است. نتایج نسبت وزن خامه قالی به وزن کل فرش نشان می دهد که در گره های متقارن و نامتقارن بیش از دو سوم وزن فرش مربوط به خامه قالی است که به این ترتیب پیش بینی می شود در کاربردهای مکانیکی نسبت به سایر نمونه ها برتری داشته باشند، در حالی که نمونه جفتی کمترین نسبت خامه مصرفی را داشته و به همین دلیل می تواند ضعیف ترین عملکرد مکانیکی را از خود نشان دهد.
In this paper، the specimens woven by the same weaver with identical materials but with four different types of knots، i.e.، symmetrical، asymmetrical، jufti and U knots، which their details are given in a previous paper by these authors، are used. The effect of these knots on such physical properties as width of the weave، length of the motifs، length of yarn in a knot and the carpet weight are measured. The woven samples are produced in two different methods. Resulrs show that the width of jufti and U knot samples were reduced after cutting off the loom، while the change in the width of the other two is little. The change in the length of motifs depends on the change in the carpet length، i.e.، in samples with change in carpet length، the motifs length change as well and in cases that there are little change or no change in the carpet length، accordingly no change or little change is observed in the motifs. In the meantime، by subjective investigation of shapes of motifs in the four different knots، the change in their details and the sharpness of the lines and curves in them are studied. The results of computation of the ratio of the wool yarn to cotton yarn demonstrates that in symmetric and asymmetric samples more than two third of the carpet weight is built up by wool yarns، so that it is predicted that they have better mechanical function compared with other knots. Jufti sample has the lowest ratio of wool to cotton yarn، so it would show the worst mechanical performance.